图书馆订阅: Guest
Begell Digital Portal Begell 数字图书馆 电子图书 期刊 参考文献及会议录 研究收集
多相流动科学与技术
SJR: 0.124 SNIP: 0.222 CiteScore™: 0.26

ISSN 打印: 0276-1459
ISSN 在线: 1943-6181

多相流动科学与技术

DOI: 10.1615/MultScienTechn.2019031211
pages 305-318

BUBBLE DEPARTURE CHARACTERISTICS IN NANOFLUID FLOW BOILING

Nirupama Patra
Department of Chemical Engineering, IIT (BHU), Varanasi-221005, UP, India
Vivek Gupta
Department of Mechanical Engineering, IIT (BHU), Varanasi-221005, UP, India
Pradyumna Ghosh
Department of Mechanical Engineering, IIT (BHU), Varanasi-221005, UP, India
R. S. Singh
Department of Chemical Engineering, IIT (BHU), Varanasi-221005, UP, India

ABSTRACT

This paper presents the results of visualization experiments that were carried out conducted to investigate the bubble departure characteristics inflow boiling of water and dilute oxide-based nanofluids. The experiments were performed under the atmospheric pressure, and liquid subcooling was around 20 K. In the experiments, bubbles were generated on a the vertical surface of a stainless steel rod containing a cartridge heater under subcooled as well as nearly saturated conditions. Bubble images were captured with a Mikrotron Motion BLITZ Cube 4 high-speed video camera. Images were analyzed with the purpose of finding bubble departure characteristics such as, i.e., bubble diameter and bubble departure frequency using ImageJ, image-processing software. Addition of nanoparticles into the base fluid decreases bubble diameter and increases the bubble departure frequency. Bubble diameter and bubble frequency increase in both water and nanofluids with increase in applied heat flux.

REFERENCES

  1. Bibeau, E. and Salcudean, M., A Study of Bubble Ebullition in Forced-Convective Subcooled Nucleate Boiling at Low Pressure, Int. J. Heat Mass Transf., vol. 37, no. 15, pp. 2245-2259, 1994.

  2. Carey, V.P., Liquid Vapor Phase Change Phenomena: An Introduction to the Thermophysics of Vaporization and Condensation Processes in Heat Transfer Equipment, Boca Raton, FL: CRC Press, 2018.

  3. Dominguez-Ontiveros, E., Fortenberry, S., and Hassan, Y.A., Experimental Observations of Flow Modifi-cations in Nanofluid Boiling Utilizing Particle Image Velocimetry, Nucl. Eng. Des., vol. 240, no. 2, pp. 299-304, 2010.

  4. Gerardi, C., Buongiorno, J., Hu, L.-W., and McKrell, T., Infrared Thermometry Study of Nanofluid Pool Boiling Phenomena, Nanoscale Res. Lett., vol. 6, no. 1, pp. 1-17, 2011.

  5. Goel, P., Nayak, A.K., Ghosh, P., and Joshi, J.B., Experimental Study of Bubble Departure Characteristics in Forced Convective Subcooled Nucleate Boiling, Exp. Heat Transf, vol. 31, pp. 194-218, 2017.

  6. Hegde, R.N., Rao, S.S., and Reddy, R., Flow Visualization and Study of Critical Heat Flux Enhancement in Pool Boiling with Al2O3-Water Nanofluids, Int. J. Therm.. Sci., vol. 16, no. 2, pp. 445-453,2012.

  7. Holman, J.P., Experimental Methods for Engineers, New York: McGraw-Hill, 1966.

  8. Jo, B., Jeon, P., Yoo, J., and Kim, H., Wide Range Parametric Study for the Pool Boiling of Nano-Fluids with a Circular Plate Heater, J. Visual, vol. 12, no. 1, pp. 37-46, 2009.

  9. Khaleduzzaman, S., Mahbubul, I., Shahrul, I., and Saidur, R., Effect of Particle Concentration, Temperature and Surfactant on Surface Tension ofNanofluids, Int. Commun. Heat Mass Transf, vol. 49, pp. 110-114, 2013.

  10. Kim, S.J., Bang, I.C., Buongiorno, J., and Hu, L., Surface Wettability Change during Pool Boiling of Nanofluids and Its Effect on Critical Heat Flux, Int. J. Heat Mass Transf., vol. 50, no. 19, pp. 4105-4116,2007.

  11. Kurul, N. and Podowski, M.Z., Multidimensional Effects in Forced Convection Subcooled Boiling, in Proc. of the 9th Int. Heat Transfer Conf, New York: Hemisphere Publishing, pp. 19-24, 1990.

  12. Li, X., Yuan, Y., and Tu, J., Modelling and Critical Analysis of Bubbly Flows of Dilute Nanofluids in a Vertical Tube, Nucl. Eng. Des., vol. 300, pp. 173-180, 2016.

  13. Pak, B.C. and Cho, Y.I., Hydrodynamic and Heat Transfer Study of Dispersed Fluids with Submicron Metallic Oxide Particles, Exp. Heat Transf., vol. 11, no. 2, pp. 151-170,1998.

  14. Park, Y.S. and Chang, S.H., Measurement of Local Two-Phase Flow Parameters ofNanofluids Using Con-ductivity Double-Sensor Probe, Nanoscale Res. Lett., vol. 6, no. 1, p. 284,2011.

  15. Patra, N., Ghosh, P., Singh, R., and Nayak, A., Flow Visualization in Dilute Oxide based Nanofluid Boiling, Int. J. Heat Mass Transf, vol. 135, pp. 331-344, 2019.

  16. Patra, N., Gupta, V., Pradyumna, E., Singh, R., Ghosh, P., Singh, R., and Nayak, A., Delay in DNB for Flow Boiling of Diluted Oxide based Nanofluids, Exp. Therm. Fluid Sci., vol. 89, pp. 211-218, 2017.

  17. Rana, K., Agrawal, G., Mathur, J., and Puli, U., Measurement of Void Fraction in Flow Boiling of ZnO- Water Nanofluids Using Image Processing Technique, Nucl. Eng. Des, vol. 270, pp. 217-226,2014.

  18. Rana, K., Rajvanshi, A., and Agrawal, G., A Visualization Study of Flow Boiling Heat Transfer with Nanofluids, J. Visual, vol. 16, no. 2, pp. 133-143,2013.

  19. Sabersky, R., Heat Transfer in the Seventies, Int. J. Heat Mass Transf., vol. 14, no. 12, pp. 1927-1949, 1971.

  20. Situ, R., Hibiki, T., Ishii, M., and Mori, M., Bubble Lift-Off Size in Forced Convective Subcooled Boiling Flow, Int. J. Heat Mass Transf., vol. 48, no. 25, pp. 5536-5548, 2005.

  21. Situ, R., Mi, Y., Ishii, M., and Mori, M., Photographic Study of Bubble Behaviors in Forced Convection Subcooled Boiling, Int. J. Heat Mass Transf, vol. 47, nos. 17-18, pp. 3659-3667, 2004.

  22. Thorncroft, G., Klausnera, J., and Mei, R., An Experimental Investigation of Bubble Growth and Detach-ment in Vertical Upflow and Downflow Boiling, Int. J. Heat Mass Transf, vol. 41, no. 23, pp. 3857-3871, 1998.

  23. Truong, B., Hu, L.-W., Buongiorno, J., and McKrell, T., Alumina Nanoparticle Pre-Coated Tubing En-hancing Subcooled Flow Boiling Critical Heat Flux, in ASME 2009 2nd Int. Conf. Micro/Nanoscale Heat Mass Transfer, American Society of Mechanical Engineers, 2009.

  24. Wang, Y. and Wu, J., Numerical Simulation on Single Bubble Behavior during Al2O3/H2O Nanofluids Flow Boiling Using Moving Particle Simi-Implicit Method, Prog. Nucl. Energy, vol. 85, pp. 130-139, 2015.

  25. Xu, L. and Xu, J., Nanofluid Stabilizes and Enhances Convective Boiling Heat Transfer in a Single Mi-crochannel, Int. J. Heat Mass Transf, vol. 55, no. 21, pp. 5673-5686, 2012.

  26. You, S., Kim, J., and Kim, K., Effect of Nanoparticles on Critical Heat Flux of Water in Pool Boiling Heat Transfer, Appl. Phys. Lett, vol. 83, no. 16, pp. 3374-3376,2003.

  27. Yuan, Y., Li, X., and Tu, J., The Effects of Nanoparticles on the Lift Force and Drag Force on Bubbles in Nanofluids: A Two-Fluid Model Study, Int. J. Therm. Sci., vol. 119, pp. 1-8,2017.

  28. Zhou, S. and Ni, R., Measurement of the Specific Heat Capacity of Water-Based Al2O3 Nanofluid, Appl. Phys. Lett., vol. 92, no. 9, p. 093123, 2008.