Abo Bibliothek: Guest
Digitales Portal Digitale Bibliothek eBooks Zeitschriften Referenzen und Berichte Forschungssammlungen
Atomization and Sprays
Impact-faktor: 1.262 5-jähriger Impact-Faktor: 1.518 SJR: 0.814 SNIP: 1.18 CiteScore™: 1.6

ISSN Druckformat: 1044-5110
ISSN Online: 1936-2684

Volumes:
Volumen 29, 2019 Volumen 28, 2018 Volumen 27, 2017 Volumen 26, 2016 Volumen 25, 2015 Volumen 24, 2014 Volumen 23, 2013 Volumen 22, 2012 Volumen 21, 2011 Volumen 20, 2010 Volumen 19, 2009 Volumen 18, 2008 Volumen 17, 2007 Volumen 16, 2006 Volumen 15, 2005 Volumen 14, 2004 Volumen 13, 2003 Volumen 12, 2002 Volumen 11, 2001 Volumen 10, 2000 Volumen 9, 1999 Volumen 8, 1998 Volumen 7, 1997 Volumen 6, 1996 Volumen 5, 1995 Volumen 4, 1994 Volumen 3, 1993 Volumen 2, 1992 Volumen 1, 1991

Atomization and Sprays

DOI: 10.1615/AtomizSpr.2013007539
pages 379-399

AN EXPERIMENT STUDY ON PHENOMENON AND MECHANISM OF FLASH BOILING SPRAY FROM A MULTI-HOLE GASOLINE DIRECT INJECTOR

Shenghua Yang
State Key Laboratory of Engines, Tianjin University, 92 Weijin Road, Tianjin 300072, China
Zhiping Song
State Key Laboratory of Engines, Tianjin University, 92 Weijin Road, Tianjin 300072, China
Tianyou Wang
State Key Laboratory of Engines, Tianjin University, 92 Weijin Road, Tianjin 300072, China
Zhuo Yao
State Key Laboratory of Engines, Tianjin University, 92 Weijin Road, Tianjin 300072, China

ABSTRAKT

Flash boiling spray could produce superior atomization and promote the formation of fuel/air mixture for a gasoline direct injection engine. However, the spray atomization deteriorates at a high degree of superheat of fuel, and the mechanism still remains unclear. In the present work, the macroscopic characteristics of flash boiling spray from a multi-hole gasoline direct injector were obtained by a Mie scattering technique to enhance understanding of the atomization process. The spray morphology and the macroscopic parameters with variations of fuel temperature and ambient pressure were analyzed. Two spray parameters were proposed to quantify the extent of spray collapse and micro-explosion, namely (1) the ratio of collapse (the ratio of penetration to width) and (2) the spray span of the near field. The correlation was identified between fuel temperature/ambient pressure and the spray characteristics (i.e., penetration, spray cone angle, spray span of near field, and ratio of collapse). By comparing the differences in spray characteristics among single-hole, two-hole, and six-hole injectors, the effects of the low-pressure core and the overlap region were decoupled. It was revealed that flash boiling spray collapse was caused by the combined effect of the low-pressure core and the overlap region. This combined effect resulted from micro-explosion and thus enhanced with increasing degree of superheat.


Articles with similar content:

EFFECT OF ETHANOL AND AMBIENT PRESSURE ON PORT-FUEL-INJECTION SPRAYS IN AN OPTICALLY ACCESSIBLE INTAKE CHAMBER
Atomization and Sprays, Vol.21, 2011, issue 5
Evatt R. Hawkes, Srinivas Padala, Sanghoon Kook
AN EXPERIMENTAL STUDY ON MICROSCOPIC CHARACTERISTICS OF FLASH BOILING SPRAY WITH EXTENDED GLARE POINT VELOCIMETRY AND SIZING
Atomization and Sprays, Vol.26, 2016, issue 5
Shenghua Yang, Ming Jia, Zhuo Yao, Shiquan Shen, Tianyou Wang
EXPERIMENTAL INVESTIGATION OF SPRAY CHARACTERISTICS OF DIESEL-METHANOL-WATER EMULSION
Atomization and Sprays, Vol.25, 2015, issue 8
Wuqiang Wang, Shenteng Cao, Dongyin Wu, Junjie Yan, Zhenzhou Pang
EFFECT OF INJECTION STRATEGY ON THE SPRAY DEVELOPMENT PROCESS IN A SINGLE-CYLINDER OPTICAL GDI ENGINE
Atomization and Sprays, Vol.25, 2015, issue 9
Sungwook Park, Jingeun Song
EXPERIMENTAL STUDY ON FLASH ATOMIZATION OF AVIATION KEROSENE
Atomization and Sprays, Vol.22, 2012, issue 2
Zhencen Fan, Wei Fan, Lin Zhao, Chuanjun Yan, Haoyi Song