年間 8 号発行
ISSN 印刷: 1065-5131
ISSN オンライン: 1563-5074
Indexed in
Heat Transfer and Pressure Drop During Evaporation and Condensation of R22 inside 9.52-mm O.D. Microfin Tubes of Different Geometries
要約
Saturated flow boiling and convective condensation experiments for oil-free Refriger-ant-22 have been carried out with a microfin tube with a new cross-section profile, as well as with two traditional microfin tubes and with a smooth one. All tubes have the same outer diameter. Data are for mass fluxes ranging from about 90 to 400 kg/m2·s. In boiling tests, the nominal saturation temperature is 5 °C, with inlet quality varying from 0.2 to 0.6 and the quality variation along the test section ranging from 0.1 to 0.5. In condensation, results are for saturation temperature equal to 35 °C, with inlet and outlet qualities of 0.8 and 0.2, respectively. The new microfin tube shows the best thermal performances among the microfin tubes tested, especially in evaporation. For this case, the enhancement factor comes up to 4. Experimental results for microfin tubes are compared with predictions of a correlation scheme recently proposed; these predictions correlate well only with data for the microfin tube with a geometry much similar to one accounted by the scheme.
-
Bukasa Jean-Pierre M. , Liebenberg Leon , Meyer Josua P. , Heat Transfer Performance During Condensation Inside Spiralled Micro-Fin Tubes , Journal of Heat Transfer, 126, 3, 2004. Crossref
-
Smit F. J. , Thome J. R. , Meyer J. P. , Heat Transfer Coefficients During Condensation of the Zeotropic Refrigerant Mixture HCFC-22/HCFC-142b , Journal of Heat Transfer, 124, 6, 2002. Crossref
-
Chen Qicheng, Sun Dongliang, Condensation heat transfer enhancement mechanism for vertical upflows by the phase separation concept at small gravity, Science Bulletin, 60, 20, 2015. Crossref
-
Chamra Louay M., Tan Meng-Onn, Kung Chea-Chun, Evaluation of existing condensation heat transfer models in horizontal micro-fin tubes, Experimental Thermal and Fluid Science, 28, 6, 2004. Crossref
-
Yun Rin, Kim Yongchan, Seo Kookjeong, Young Kim Ho, A generalized correlation for evaporation heat transfer of refrigerants in micro-fin tubes, International Journal of Heat and Mass Transfer, 45, 10, 2002. Crossref
-
Bukasa Jean-Pierre, Liebenberg Leon, Meyer Josua P., Influence of Spiral Angle on Heat Transfer during Condensation inside Spiralled Micro-Fin Tubes, Heat Transfer Engineering, 26, 7, 2005. Crossref
-
Siddique Mansoor, Alhazmy Majed, Experimental study of turbulent single-phase flow and heat transfer inside a micro-finned tube, International Journal of Refrigeration, 31, 2, 2008. Crossref
-
Goldstein R.J, Eckert E.R.G, Ibele W.E, Patankar S.V, Simon T.W, Kuehn T.H, Strykowski P.J, Tamma K.K, Bar-Cohen A, Heberlein J.V.R, Davidson J.H, Bischof J, Kulacki F.A, Kortshagen U, Garrick S, Heat transfer: a review of 1998 literature, International Journal of Heat and Mass Transfer, 44, 2, 2001. Crossref
-
Copetti Jacqueline Biancon, Macagnan Mario Henrique, de Souza Daiana, Oliveski Rejane De Césaro, Experiments with micro-fin tube in single phase, International Journal of Refrigeration, 27, 8, 2004. Crossref
-
Filho Enio P.Bandarra, Jabardo José M.Saiz, Barbieri Paulo E.L., Convective boiling pressure drop of refrigerant R-134a in horizontal smooth and microfin tubes, International Journal of Refrigeration, 27, 8, 2004. Crossref
-
Dalkilic A.S., Wongwises S., Intensive literature review of condensation inside smooth and enhanced tubes, International Journal of Heat and Mass Transfer, 52, 15-16, 2009. Crossref
-
Cavallini A., Del Col D., Doretti L., Longo G.A., Rossetto L., Heat transfer and pressure drop during condensation of refrigerants inside horizontal enhanced tubes, International Journal of Refrigeration, 23, 1, 2000. Crossref
-
Chen Qicheng, Xu Jinliang, Sun Dongliang, The bubble leakage mechanism for vertical upflows by the phase separation concept, Chinese Science Bulletin, 59, 21, 2014. Crossref
-
Chamra Louay M., Mago Pedro J., Tan Meng-Onn, Kung Chea-Chun, Modeling of condensation heat transfer of pure refrigerants in micro-fin tubes, International Journal of Heat and Mass Transfer, 48, 7, 2005. Crossref
-
Wang Wei-Juan, Zhao Ling-Xiao, Zhang Chun-Lu, Generalized neural network correlation for flow boiling heat transfer of R22 and its alternative refrigerants inside horizontal smooth tubes, International Journal of Heat and Mass Transfer, 49, 15-16, 2006. Crossref
-
Shah Mirza M., Unified correlation for heat transfer during boiling in plain mini/micro and conventional channels, International Journal of Refrigeration, 74, 2017. Crossref
-
Sun Zhi-chuan, Li Wei, A new general correlation for frictional pressure drop during condensation inside horizontal micro-fin tubes, International Journal of Heat and Mass Transfer, 112, 2017. Crossref
-
Saha Sujoy Kumar, Ranjan Hrishiraj, Emani Madhu Sruthi, Bharti Anand Kumar, Flow Boiling Enhancement Techniques, in Two-Phase Heat Transfer Enhancement, 2020. Crossref
-
Thome John R., Flow Boiling Inside Microfin Tubes: Recent Results and Design Methods, in Heat Transfer Enhancement of Heat Exchangers, 1999. Crossref
-
Saha Sujoy Kumar, Ranjan Hrishiraj, Emani Madhu Sruthi, Bharti Anand Kumar, Convective Condensation, in Two-Phase Heat Transfer Enhancement, 2020. Crossref
-
Chamra L M, Mago P J, Tan M-O, Kung C-C, Modelling of evaporation and condensation pressure drop in microfin tubes, Proceedings of the Institution of Mechanical Engineers, Part C: Journal of Mechanical Engineering Science, 219, 1, 2005. Crossref
-
Chamra L M, Mago P J, Modelling of evaporation heat transfer of pure refrigerants and refrigerant mixtures in microfin tubes, Proceedings of the Institution of Mechanical Engineers, Part C: Journal of Mechanical Engineering Science, 221, 4, 2007. Crossref
-
Nhan Phan Thanh, A Review on Condensation Process of Refrigerants in Horizontal Microfin Tubes: A Typical Example, in Heat Transfer [Working Title], 2022. Crossref