Inscrição na biblioteca: Guest
Portal Digital Begell Biblioteca digital da Begell eBooks Diários Referências e Anais Coleções de pesquisa
Atomization and Sprays
Fator do impacto: 1.262 FI de cinco anos: 1.518 SJR: 0.814 SNIP: 1.18 CiteScore™: 1.6

ISSN Imprimir: 1044-5110
ISSN On-line: 1936-2684

Volumes:
Volume 29, 2019 Volume 28, 2018 Volume 27, 2017 Volume 26, 2016 Volume 25, 2015 Volume 24, 2014 Volume 23, 2013 Volume 22, 2012 Volume 21, 2011 Volume 20, 2010 Volume 19, 2009 Volume 18, 2008 Volume 17, 2007 Volume 16, 2006 Volume 15, 2005 Volume 14, 2004 Volume 13, 2003 Volume 12, 2002 Volume 11, 2001 Volume 10, 2000 Volume 9, 1999 Volume 8, 1998 Volume 7, 1997 Volume 6, 1996 Volume 5, 1995 Volume 4, 1994 Volume 3, 1993 Volume 2, 1992 Volume 1, 1991

Atomization and Sprays

DOI: 10.1615/AtomizSpr.2016014272
pages 1241-1257

EFFECT OF THE PROPELLANT MASS FRACTION IN A BINARY MIXTURE ON THE SPRAY CHARACTERISTICS AS GENERATED BY HOMOGENEOUS FLASH BOILING

Moti Levy
Faculty of Aerospace Engineering, Technion - Israel Institute of Technology, Haifa, Israel
Yeshayahou Levy
Faculty of Aerospace Engineering, Technion - Israel Institute of Technology, Haifa, Israel
Eran Sher
Ben-Gurion University of Negev, Israel

RESUMO

When a binary mixture of a high vapor pressure propellant and a low vapor pressure component is injected through a simple atomizer at high enough pressure, flash boiling of the propellant may occur. Due to the sudden depressurization, propellant-vapor nuclei are developed to a rapid evaporation, resulting in break-up of the liquid mixture into a fine spray that is characterized by tiny and fairly uniform droplets. This method is presently used in quite a number of applications. Depending on the initial conditions we distinguish between heterogeneous and homogeneous nucleation. Flash-boiling process within the aperture leads to highly efficient atomization. Finer sprays are achieved when increasing the superheating degree; thus, homogeneous nucleation is apparently the preferred regime for atomization. Nevertheless, experimental studies involving atomization under homogeneous nucleation regime are rather scarce. In the present work we study the effect of the propellant mass fraction in a binary mixture on the spray characteristics as generated by a homogeneous flash-boiling process. We have selected Chlorodifluoromethane (CHClF2 or R-22), and PMX-200 silicon oil as the two components of the mixture and studied the effect of the mixing ratio on the droplets' velocity and size distribution and the radial distribution of the droplets' velocity and size. We used a TSI's Phase Doppler Particle Analyzer (PDPA) to characterize the spray, and a controlled 3D positioning system to measure the droplets characteristics at accurate and specific positions. We show that lowering the mass fraction of the propellant results in a progressively higher value of the mean velocity at any radial distance, a higher mean droplets' size, and a higher standard deviation. For the present homogeneous nucleation flash-boiling atomization system, we found that the break-up efficiency, as defined by Sher and Zeigerson-Katz [Atomization Sprays, vol. 6, no. 4 (1996)], is rather low, on the order of 10−6, while a higher propellant mass fraction yields a lower process efficiency. The lower efficiency is attributed to the different mechanisms of spray formation in homogeneous and heterogeneous nucleation.


Articles with similar content:

TRANSIENT BURNING BEHAVIOR OF SOLID PROPELLANTS
International Journal of Energetic Materials and Chemical Propulsion, Vol.3, 1994, issue 1-6
Yeu-Cherng Lu, F. R. Schwam, Y. J. Yim
Radiative Properties of Aluminized Propellant Flames
International Heat Transfer Conference 8, Vol.2, 1986, issue
M. Quinn Brewster
TRANSIENT BURNING BEHAVIOR OF PHASE-STABILIZED AMMONIUM NITRATE BASED AIRBAG PROPELLANT
International Journal of Energetic Materials and Chemical Propulsion, Vol.11, 2012, issue 5
Eric Boyer, Jonathan T. Essel, Baoqi Zhang, Kenneth K. Kuo
UNSTEADINESS IN EFFERVESCENT SPRAYS
Atomization and Sprays, Vol.9, 1999, issue 1
John T. K. Luong
CHARACTERIZATION OF A POLYDISPERSED PARTICLE-LADEN JET USING A PHASE DOPPLER ANEMOMETER
ICLASS 94
Proceedings of the Sixth International Conference on Liquid Atomization and Spray Systems, Vol.0, 1994, issue
H.-J. Nuglisch, F. Prevost, J. Boree, G. Charnay