Inscrição na biblioteca: Guest
Portal Digital Begell Biblioteca digital da Begell eBooks Diários Referências e Anais Coleções de pesquisa
Atomization and Sprays
Fator do impacto: 1.262 FI de cinco anos: 1.518 SJR: 0.814 SNIP: 1.18 CiteScore™: 1.6

ISSN Imprimir: 1044-5110
ISSN On-line: 1936-2684

Volumes:
Volume 29, 2019 Volume 28, 2018 Volume 27, 2017 Volume 26, 2016 Volume 25, 2015 Volume 24, 2014 Volume 23, 2013 Volume 22, 2012 Volume 21, 2011 Volume 20, 2010 Volume 19, 2009 Volume 18, 2008 Volume 17, 2007 Volume 16, 2006 Volume 15, 2005 Volume 14, 2004 Volume 13, 2003 Volume 12, 2002 Volume 11, 2001 Volume 10, 2000 Volume 9, 1999 Volume 8, 1998 Volume 7, 1997 Volume 6, 1996 Volume 5, 1995 Volume 4, 1994 Volume 3, 1993 Volume 2, 1992 Volume 1, 1991

Atomization and Sprays

DOI: 10.1615/AtomizSpr.2013007539
pages 379-399

AN EXPERIMENT STUDY ON PHENOMENON AND MECHANISM OF FLASH BOILING SPRAY FROM A MULTI-HOLE GASOLINE DIRECT INJECTOR

Shenghua Yang
State Key Laboratory of Engines, Tianjin University, 92 Weijin Road, Tianjin 300072, China
Zhiping Song
State Key Laboratory of Engines, Tianjin University, 92 Weijin Road, Tianjin 300072, China
Tianyou Wang
State Key Laboratory of Engines, Tianjin University, 92 Weijin Road, Tianjin 300072, China
Zhuo Yao
State Key Laboratory of Engines, Tianjin University, 92 Weijin Road, Tianjin 300072, China

RESUMO

Flash boiling spray could produce superior atomization and promote the formation of fuel/air mixture for a gasoline direct injection engine. However, the spray atomization deteriorates at a high degree of superheat of fuel, and the mechanism still remains unclear. In the present work, the macroscopic characteristics of flash boiling spray from a multi-hole gasoline direct injector were obtained by a Mie scattering technique to enhance understanding of the atomization process. The spray morphology and the macroscopic parameters with variations of fuel temperature and ambient pressure were analyzed. Two spray parameters were proposed to quantify the extent of spray collapse and micro-explosion, namely (1) the ratio of collapse (the ratio of penetration to width) and (2) the spray span of the near field. The correlation was identified between fuel temperature/ambient pressure and the spray characteristics (i.e., penetration, spray cone angle, spray span of near field, and ratio of collapse). By comparing the differences in spray characteristics among single-hole, two-hole, and six-hole injectors, the effects of the low-pressure core and the overlap region were decoupled. It was revealed that flash boiling spray collapse was caused by the combined effect of the low-pressure core and the overlap region. This combined effect resulted from micro-explosion and thus enhanced with increasing degree of superheat.


Articles with similar content:

EFFECT OF NOZZLE CONFIGURATION ON MACROSCOPIC SPRAY CHARACTERISTICS OF MULTI-HOLE FUEL INJECTORS UNDER SUPERHEATED CONDITIONS
Atomization and Sprays, Vol.26, 2016, issue 5
Gele Aori, Ming Zhang, David L. S. Hung, Tianyun Li, Gaomimg Zhang
INVESTIGATION OF RAPID ATOMIZATION AND COLLAPSE OF SUPERHEATED LIQUID FUEL SPRAY UNDER SUPERHEATED CONDITIONS
Atomization and Sprays, Vol.26, 2016, issue 12
Hujie Pan, David L. S. Hung, Tianyun Li, Min Xu, Shengqi Wu
MACROSCOPIC CHARACTERIZATION OF FLASH-BOILING MULTIHOLE SPRAYS USING PLANAR LASER-INDUCED EXCIPLEX FLUORESCENCE. PART II: CROSS-SECTIONAL SPRAY STRUCTURE
Atomization and Sprays, Vol.23, 2013, issue 3
David J. Cleary, Ming Zhang, Yuyin Zhang, Min Xu, Gaomimg Zhang
ANALYZING THE CYCLE-TO-CYCLE VARIATIONS OF PULSING SPRAY CHARACTERISTICS BY MEANS OF THE PROPER ORTHOGONAL DECOMPOSITION
Atomization and Sprays, Vol.23, 2013, issue 7
Min Xu, Jie Zhong, David L. S. Hung, Hao Chen
MORPHOLOGICAL EXPLORATION OF EMERGING JET FLOWS FROM MULTI-HOLE DIESEL INJECTORS AT DIFFERENT NEEDLE LIFTS
Atomization and Sprays, Vol.25, 2015, issue 5
Xusheng Zhang, Jin Wang, Xingbin Xie, Kamel Fezzaa, Fengkun Wang, Jian Gao, Eric M. Dufresne, Seoksu Moon, Ming Chia Lai