Доступ предоставлен для: Guest

INVASION OF PRESSURIZED CLAY SUSPENSIONS INTO GRANULAR SOIL

Том 16, Выпуск 4, 2013, pp. 351-365
DOI: 10.1615/JPorMedia.v16.i4.70
Get accessGet access

Краткое описание

Soil plastering is important in trenchless tunneling to ensure the stability and the integrity of the wall of a borehole. Two key processes in soil plastering with clay suspensions are viscous invasion (mud spurt) and filter cake formation. This study describes the conditions under which these two different processes occur. The results of experimental and theoretical developments are compared with some data from tunneling projects. Filter cake formation can only commence when the invasion velocity falls below the Peclet criterion for undrained behavior of the suspension. Whether a deep layer of invaded clay suspension or a filter cake develops (and situations in between) depends on the ratio between the time scale of viscous invasion and the time scale of filter cake formation. In clay suspensions with quartz flour filler or suspended sand, filter cake formation commenced earlier, in agreement with classical filter rules for filter cake formation. The analysis shows how the permeable compressible fabric of colloids influences invasion depth. The presented concept, in which consolidation and rheology are considered, can be utilized to develop drilling fluids designed for specific tasks in tunneling and drilling for hydrocarbon reservoirs. The test results can be used as verification material for porous media models containing a fluid with a permeable compressive fabric of colloids.

ЦИТИРОВАНО В
  1. References, in Reservoir Formation Damage, 2016. Crossref

  2. Ichim A. C., Teodoriu C.. , Reflections on Overall Heat Transfer Coefficient with Application to Thermal Well Design, Day 3 Wed, November 30, 2016, 2016. Crossref

  3. Xu Tao, Bezuijen Adam, Analytical methods in predicting excess pore water pressure in front of slurry shield in saturated sandy ground, Tunnelling and Underground Space Technology, 73, 2018. Crossref

  4. Küpferle Jakob, Zizka Zdenek, Schoesser Britta, Röttger Arne, Alber Michael, Thewes Markus, Theisen Werner, Influence of the slurry-stabilized tunnel face on shield TBM tool wear regarding the soil mechanical changes – Experimental evidence of changes in the tribological system, Tunnelling and Underground Space Technology, 74, 2018. Crossref

  5. Zhang Zixin, Yin Tong, A Coupled CFD–DEM Simulation of Slurry Infiltration and Filter Cake Formation during Slurry Shield Tunneling, Infrastructures, 3, 2, 2018. Crossref

  6. Zizka Zdenek, Schoesser Britta, Thewes Markus, Schanz Tom, Slurry Shield Tunneling: New Methodology for Simplified Prediction of Increased Pore Pressures Resulting from Slurry Infiltration at the Tunnel Face Under Cyclic Excavation Processes, International Journal of Civil Engineering, 17, 1, 2019. Crossref

  7. Zhang Zixin, Yin Tong, Huang Xin, Dias Daniel, Slurry filtration process and filter cake formation during shield tunnelling: Insight from coupled CFD-DEM simulations of slurry filtration column test, Tunnelling and Underground Space Technology, 87, 2019. Crossref

  8. Xu Tao, Bezuijen Adam, Zhou Wan-Huan, Pressure Infiltration Characteristics of Foam for EPB Shield Tunnelling, in Geotechnics for Sustainable Infrastructure Development, 62, 2020. Crossref

  9. Xu Tao, Bezuijen Adam, Experimental study on the mechanisms of bentonite slurry penetration in front of a slurry TBM, Tunnelling and Underground Space Technology, 93, 2019. Crossref

  10. Zhou Xiong, Yang Yuyou, Effect of Foam Parameters on Cohesionless Soil Permeability and Its Application to Prevent the Water Spewing, Applied Sciences, 10, 5, 2020. Crossref

  11. Zizka Zdenek, Kube Sebastian, Schößer Britta, Thewes Markus, Influence of stagnation gradient for face support calculation in Slurry Shield Tunnelling, Geomechanics and Tunnelling, 13, 4, 2020. Crossref

  12. Mao Jiahua, Yuan Dajun, Jin Dalong, Wang Binghui, Wu Shangkun, Experimental Study on Electrical Resistivity Characteristics of Saturated Sand Mixes with Bentonite Slurry, Applied Sciences, 11, 24, 2021. Crossref

  13. Qian Yongjin, Zhu Wei, Zhang Ning, Min Fanlu, Wu Silin, Simple Filter Cake Formation Test Method Using a Geotextile instead of the Sand Stratum, KSCE Journal of Civil Engineering, 26, 1, 2022. Crossref

  14. Xu T., Bezuijen A., Pressure infiltration characteristics of bentonite slurry, Géotechnique, 69, 4, 2019. Crossref

  15. Zheng Dongzhu, Bezuijen Adam, Thewes Markus, An experimental study on foam infiltration into saturated sand and its consequence for EPB shield tunneling, Tunnelling and Underground Space Technology, 111, 2021. Crossref

  16. Xu Tao, Bezuijen Adam, Bentonite slurry infiltration into sand: filter cake formation under various conditions, Géotechnique, 69, 12, 2019. Crossref

  17. Lin Yufeng, Fang Yong, He Chuan, Wang Wei, Experimental study on degree of match between slurry and ground based on particle retention rate, Tunnelling and Underground Space Technology, 116, 2021. Crossref

  18. Kou Lei, Zhao Jinjie, Lian Fanglei, Miao Ronghu, Lei Mingfeng, Experimental Study on the Formation and Characteristics of Mud Filtration Cake in Large-Diameter Slurry Shield Tunneling, Advances in Civil Engineering, 2021, 2021. Crossref

  19. Mao Jiahua, Yuan Dajun, Jin Dalong, Liu Shengnan, Influence of Cutting Tools on Filter Cake Formation during Slurry Shield Tunnelling, KSCE Journal of Civil Engineering, 25, 6, 2021. Crossref

  20. Yin Tong, Zhang Zixin, Huang Xin, Shire Thomas, Hanley Kevin J., On the morphology and pressure-filtration characteristics of filter cake formation: Insight from coupled CFD–DEM simulations, Tunnelling and Underground Space Technology, 111, 2021. Crossref

  21. Yin Xinsheng, Chen Renpeng, Meng Fanyan, Ding Zhi, Cui Yunliang, Hedayat Ahmadreza, Mooney Michael, Face stability of slurry-driven shield with permeable filter cake, Tunnelling and Underground Space Technology, 111, 2021. Crossref

  22. Lei H., Liu X., Shi F., Ma C., Infiltration behaviour into sand of bentonite slurry with guar gum, Géotechnique Letters, 12, 3, 2022. Crossref

  23. Xu Tao, Bezuijen Adam, Thewes Markus, Pressure infiltration characteristics of foam for EPB shield tunnelling in saturated sand – part 2: soil–foam mixture, Géotechnique, 72, 4, 2022. Crossref

  24. Hu Xiongyu, Fang Yong, Walton Gabriel, He Chuan, Laboratory model test of slurry shield tunnelling in saturated sandy soil, Géotechnique, 2022. Crossref

  25. Hou Chuantan, Pan Qiujing, Xu Tao, Huang Fu, Yang Xiaoli, Three-dimensional tunnel face stability considering slurry pressure transfer mechanisms, Tunnelling and Underground Space Technology, 125, 2022. Crossref

  26. Xu Tao, Bezuijen Adam, Thewes Markus, Pressure infiltration characteristics of foam for EPB shield tunnelling in saturated sand – part 1: ‘clean’ foam, Géotechnique, 72, 4, 2022. Crossref

  27. Lu Zhao, Zhou Wan-Huan, Yin Zhen-Yu, Effect of Viscosity on Slurry Infiltration in Granular Media, International Journal of Geomechanics, 22, 9, 2022. Crossref

  28. Lu Zhao, Zhou Wan-Huan, Yin Zhen-Yu, Yang Jie, Numerical modeling of viscous slurry infiltration in sand, Computers and Geotechnics, 146, 2022. Crossref

  29. Zizka Zdenek, Schoesser Britta, Thewes Markus, Investigations on transient support pressure transfer at the tunnel face during slurry shield drive part 1: Case A – Tool cutting depth exceeds shallow slurry penetration depth, Tunnelling and Underground Space Technology, 118, 2021. Crossref

  30. Liu Dongshuang, Liu Xinrong, Han Yafeng, Xiong Fei, Liu Ronghan, Lin Chengqian, Deng Zhiyun, Xiao Yu, Luo Weibang, Model Test on the Passive Failure of Slurry Shield Tunneling in Circular‐Gravel Stratum, Earth and Space Science, 9, 6, 2022. Crossref

  31. Zizka Zdenek, Schoesser Britta, Thewes Markus, Investigations on the transient support pressure transfer at the tunnel face during slurry shield drive Part 2: Case B – Deep slurry penetration exceeds tool cutting depth, Tunnelling and Underground Space Technology, 118, 2021. Crossref

  32. Lin Yufeng, Fang Yong, He Chuan, Numerical study on clogging mechanism of slurry infiltration in porous media based on coupled CFD-DEM method, Tunnelling and Underground Space Technology, 128, 2022. Crossref

  33. Xu Tao, Zhou Wan-Huan, Bezuijen Adam, Qin Su, Effects of sand and slurry characteristics on pressure infiltration of bentonite slurry into sand, Géotechnique, 2022. Crossref

  34. Gao Yi, Liu Zhen, Zhou Cuiying, Bhattarai Ajaya, Study on the properties of mud films derived from naturally weathered red-bed soil under pressureless conditions, PLOS ONE, 17, 10, 2022. Crossref

  35. Liu Keqi, Ding Wantao, Qu Chunxu, A Mesoscopic Viewpoint on Slurry Penetration and Pressure Transfer Mechanisms for Slurry Shield Tunneling, Buildings, 12, 10, 2022. Crossref

  36. Zheng Dongzhu, Bezuijen Adam, Thewes Markus, Modelling the infiltration behaviour of foam into saturated sand considering capillary resistance for EPB shield tunnelling, Géotechnique, 2022. Crossref

  37. Liu Yuhang, Wei Linchun, Zhu Yanfei, Zhuang Xiaoying, Local Stability in the Process of Excavation Located in High Permeability Saturated Sand of Diaphragm Wall Construction, Applied Mechanics, 3, 4, 2022. Crossref

Статьи, принятые к публикации

Effects of Momentum Slip and Convective Boundary Condition on a Forced Convection in a Channel Filled with Bidisperse Porous Medium (BDPM) Vanengmawia PC, Surender Ontela ON THERMAL CONVECTION IN ROTATING CASSON NANOFLUID PERMEATED WITH SUSPENDED PARTICLES IN A DARCY-BRINKMAN POROUS MEDIUM Pushap Sharma, Deepak Bains, G. C. Rana Effect of Microstructures on Mass Transfer inside a Hierarchically-structured Porous Catalyst Masood Moghaddam, Abbas Abbassi, Jafar Ghazanfarian Insight into the impact of melting heat transfer and MHD on stagnation point flow of tangent hyperbolic fluid over a porous rotating disk Priya Bartwal, Himanshu Upreti, Alok Kumar Pandey Numerical Simulation of 3D Darcy-Forchheimer Hybrid Nanofluid Flow with Heat Source/Sink and Partial Slip Effect across a Spinning Disc Bilal Ali, Sidra Jubair, Md Irfanul Haque Siddiqui Fractal model of solid-liquid two-phase thermal transport characteristics in the rough fracture network shanshan yang, Qiong Sheng, Mingqing Zou, Mengying Wang, Ruike Cui, Shuaiyin Chen, Qian Zheng Application of Artificial Neural Network for Modeling of Motile Microorganism-Enhanced MHD Tangent Hyperbolic Nanofluid across a vertical Slender Stretching Surface Bilal Ali, Shengjun Liu, Hongjuan Liu Estimating the Spreading Rates of Hazardous Materials on Unmodified Cellulose Filter Paper: Implications on Risk Assessment of Transporting Hazardous Materials Heshani Manaweera Wickramage, Pan Lu, Peter Oduor, Jianbang Du ELASTIC INTERACTIONS BETWEEN EQUILIBRIUM PORES/HOLES IN POROUS MEDIA UNDER REMOTE STRESS Kostas Davanas Gravity modulation and its impact on weakly nonlinear bio-thermal convection in a porous layer under rotation: a Ginzburg-Landau model approach Michael Kopp, Vladimir Yanovsky Pore structure and permeability behavior of porous media under in-situ stress and pore pressure: Discrete element method simulation on digital core Jun Yao, Chunqi Wang, Xiaoyu Wang, Zhaoqin Huang, Fugui Liu, Quan Xu, Yongfei Yang Influence of Lorentz forces on forced convection of Nanofluid in a porous lid driven enclosure Yi Man, Mostafa Barzegar Gerdroodbary SUTTERBY NANOFLUID FLOW WITH MICROORGANISMS AROUND A CURVED EXPANDING SURFACE THROUGH A POROUS MEDIUM: THERMAL DIFFUSION AND DIFFUSION THERMO IMPACTS galal Moatimid, Mona Mohamed, Khaled Elagamy CHARACTERISTICS OF FLOW REGIMES IN SPIRAL PACKED BEDS WITH SPHERES Mustafa Yasin Gökaslan, Mustafa Özdemir, Lütfullah Kuddusi Numerical study of the influence of magnetic field and throughflow on the onset of thermo-bio-convection in a Forchheimer‑extended Darcy-Brinkman porous nanofluid layer containing gyrotactic microorganisms Arpan Garg, Y.D. Sharma, Subit K. Jain, Sanjalee Maheshwari A nanofluid couple stress flow due to porous stretching and shrinking sheet with heat transfer A. B. Vishalakshi, U.S. Mahabaleshwar, V. Anitha, Dia Zeidan ROTATING WAVY CYLINDER ON BIOCONVECTION FLOW OF NANOENCAPSULATED PHASE CHANGE MATERIALS IN A FINNED CIRCULAR CYLINDER Noura Alsedais, Sang-Wook Lee, Abdelraheem Aly Porosity Impacts on MHD Casson Fluid past a Shrinking Cylinder with Suction Annuri Shobha, Murugan Mageswari, Aisha M. Alqahtani, Asokan Arulmozhi, Manyala Gangadhar Rao, Sudar Mozhi K, Ilyas Khan CREEPING FLOW OF COUPLE STRESS FLUID OVER A SPHERICAL FIELD ON A SATURATED BIPOROUS MEDIUM Shyamala Sakthivel , Pankaj Shukla, Selvi Ramasamy
Портал Begell Электронная Бибилиотека e-Книги Журналы Справочники и Сборники статей Коллекции Цены и условия подписки Begell House Контакты Language English 中文 Русский Português German French Spain