Выходит 8 номеров в год
ISSN Печать: 1065-5131
ISSN Онлайн: 1563-5074
Indexed in
STEAM CONDENSATION ON COPPER-ENHANCED TUBES USED IN AN ABSORPTION REFRIGERATION SYSTEM
Краткое описание
For the condenser of an absorption refrigerator, many enhanced geometries (smooth, corrugated, notched, floral, etc.) have been developed and are used in the field. However, no quantitative condensation heat transfer data is available in the literature. In the present study, seven enhanced tubes (floral, notched, endcross, corrugated, endcross floral, notched floral, endcross corrugated) used for condensers of absorption refrigerators were tested at the saturation temperature 40° C. Results showed that significant enhancements of condensation heat transfer were noted, especially for compound enhanced tubes. At the wall subcooling 2°C, the enhancement was 133% for the endcross corrugated tube, 77% for the endcross floral tube, and 73% for the notched floral tube. Between the notched and endcross tubes, larger enhancement was obtained from the notched tube (62% vs. 43%). The corrugated tube also yielded a significant amount (51%) of enhancement. In general, compound enhanced tubes showed higher heat transfer coefficients than single enhanced tubes. Of single enhancement geometries, three-dimensional shapes (notch, endcross) yielded higher enhancements than the floral shape and yielded approximately equal enhancements to the corrugated shape.
-
An, F.-L. and Kim, N.-H., Pool Boiling Performance of Lithium Bromide Solution on Low-Fin Tubes, J. Enhanced Heat Transf., vol. 21, pp. 37-321, 214.
-
Baiser, M. and Briggs, A., Condensation of Steam on Pin-Fin Tubes: Effect of Circumferential Pin Thickness and Spacing, Heat Transf. Eng., vol. 30, no. 13, pp. 117-123,2009.
-
Bisetto, A., Bortonin, S., and Del Col, D., Experimental Analysis of Steam Condensation over Conventional and Super-Hydrophilic Vertical Surfaces, Exp. Therm FluidSci., vol. 68, pp. 216-227,2015.
-
Del Col, D., Partin, R., Bisetto, A., Bortonin, S., and Martucci, A., Film Condensation of Steam Flowing on a Hydrophobic Surface, Int. J. Heat Mass Transf, vol. 107, pp. 307-318, 2017.
-
Dittus, F.W. and Boelter, L.M.K., Heat Transfer in Automobile Radiators of the Tubular Type, Univ. Calif. Publ. Eng., vol. 2, pp. 433-461,1930.
-
Jaber, M.H. and Webb, R.L., Enhanced Ttubes for Steam Condensers, Exp. Heat Transf., vol. 6, pp. 35-54, 1993.
-
Kim, N.-H., Steam Condensation Enhancement and Fouling in Titanium Corrugated Tubes, J. Enhanced Heat Transf., vol. 26, pp. 59-74, 2019.
-
Kim, N.-H., Personal Communication with Worldenergy Co., from www.worldenergy.com, 2020.
-
Kline, S.J. and McClintock, F.A., The Description of Uncertainties in Single Sample Experiments, Mech. Eng., vol. 75, pp. 3-9, 1953.
-
Kumar, R., Varma, H.H., Mohanty, B., and Agrawal, K.N., Augmentation of Heat Transfer during Filmwise Condensation of Steam and R-134a over Single Horizontal Finned Tubes, Int. J. Heat Mass Transf., vol. 45, pp. 21-211, 2002.
-
Mills, A.F., Hubbard, G.L., James, R.K., and Tan, C., Experimental Study of Film Condensation on Horizontal Grooved Tubes, Desalination, vol. 16, pp. 121-133,1975.
-
Mitrou, E., Film Condensation Heat Transfer on Horizontal Finned Tubes, Thesis, Naval Postgraduate School, Monterey, CA, 1985.
-
Murase, T., Wang, H.S., and Rose, J.W., Effect of Innundation for Condensation of Steam on Smooth and Enhanced Condenser Tubes, Int. J. Heat Mass Transf., vol. 49, pp. 3180-3189,2006.
-
Nusselt, W., Die Overflachen-Kondensation des Wasserdamphes, Z. Ver. Deut. Ing., vol. 60, pp. 541-569, 1916.
-
Peng, B., Ma, X., Lan, Z., Xu, W., and Wen, R., Experimental Investigation on Steam Condensation Heat Transfer Enhancement with Vertically Patterned Hydrophobic-Hydrophilic Hybrid Surfaces, Int. J. Heat Mass Transf., vol. 83, pp. 27-38,2015.
-
Sim, Y.-S. and Kim, N.-H., Pool Boiling Performance of Lithium Bromide Solution on Enhanced Tubes, J. Mech. Sci. Technol., vol. 29, pp. 2555-2563, 2015.
-
Stoecker, W.F. and Jones, J.W., Refrigeration and Air Conditioning, 2nd Ed., McGraw-Hill Pub., 1982.
-
Wanniarachchi, A.S., Marto, P. J., and Rose, J.W., Filmwise Condensation of Steam on Externally Finned Horizontal Tubes, in Fundamentals ofPhase Change: Boiling and Condensation, C.T. Avedisian and T.M. Rudy, Eds., ASME-HTD, vol. 38, pp. 133-141, 1984.
-
Wanniarachchi, A.S., Marto, P. J., and Rose, J.W., Filmwise Condensation of Steam on Horizontal Finned Tubes: Effect of Fin Spacing, Thickness and Height, in Multiphase Flow and Heat Transf., V.K. Dhir, J.C. Chen, and O.C. Jones, Eds., ASME-HTD, vol. 47, no. 1, pp. 93-99, 1985.
-
Wanniarachchi, A.S., Marto, P. J., and Rose, J.W., Filmwise Condensation of Steam on Horizontal Finned Tubes: Effect of Fin Spacing, J. Heat Transf, vol. 108, pp. 960-966,1986.
-
Webb, R.L. and Kim, N.-H., Principles of Enhanced Heat Transfer, 2nd ed., Taylor and Francis Pub., 2005.
-
Wilson, E.E., A Basis for Rational Design of Heat Transfer Apparatus, Trans. ASME, vol. 37, pp. 47-70, 1915.
-
Yau, K.K., Cooper, J.R., and Rose, J.W., Effect of Fin Spacing on the Performance of Horizontal Integral Fin Condenser Tubes, J. Heat Transf., vol. 102, pp. 20-25,1985.
-
Yau, K.K., Cooper, J.R., and Rose, J.W., Horizontal Plain and Low-Finned Condenser Tubes - Effect of Fin Spacing and Drainage Strips on Heat Transfer and Condensate Retention, J. Heat Transf., vol. 108, pp. 946-950,1986.
-
Zhang, L., Yang, S., and Xu, H., Experimental Study on Condensation Heat Transfer Characteristics of Steam on Horizontal Twisted Elliptical Tubes, Appl. Energy, vol. 97, pp. 881-887, 2012.
-
Cheng Lixin, Chai Lei, Guo Zhixiong, THERMAL ENERGY, PROCESS, AND TRANSPORT INTENSIFICATION - A BRIEF REVIEW OF LITERATURE IN 2021 AND PROSPECTS , Heat Transfer Research, 53, 18, 2022. Crossref