ライブラリ登録: Guest
Multiphase Science and Technology

年間 4 号発行

ISSN 印刷: 0276-1459

ISSN オンライン: 1943-6181

SJR: 0.144 SNIP: 0.256 CiteScore™:: 1.1 H-Index: 24

Indexed in

アクセスを得る(open in a new tab)
もっと
購入する $85.00(open in a new tab) サブスクリプションを確認する MARCレコードをダウンロード(open in a new tab) 権限を取得する(open in a new tab)

ANALYSIS OF FLOW AND PARTICLE SETTLING IN A CONTINUOUS SETTLING TANK: CFD STUDY

巻 34, 発行 1, 2022, pp. 1-21
DOI: 10.1615/MultScienTechn.2021039741
Get accessGet access
Amol V. Ganjare
Department of Chemical Engineering, Institute of Chemical Technology, Mumbai-400019, India
Ashwin W. Patwardhan
Department of Chemical Engineering, Institute of Chemical Technology, Matunga, Mumbai 400019, India

要約

In the present work, the hydrodynamics and particle separation in a settling tank were studied using the Euler-Euler and Euler-Lagrange approaches. The computational fluid dynamics (CFD) model was validated using data obtained from an ultrasonic velocity profiler. The presence of the particles and their impact on the flow patterns were investigated. The presence of the particles in the settling tank lead to changes in the flow patterns. This phenomenon was evaluated through experiments and simulations. The behavior of different particles was studied using discrete phase model tracking. The effects of the feedwell diameter and height on the flow patterns were studied to select the optimized feedwell parameters. The dependency of the direction of the motion of the particles on the terminal settling velocity and the overflow rate was explored. Since the local conditions inside the settling tank are important, the effects of the flow rate, particle density, and concentration were studied in terms of the separation efficiency.

キーワード: gravity settling, ultrasonic velocity profiler, discrete phase model particle tracking, recirculation zones, particle separation
参考

  1. Abid, R., Evaluation of Two-Equation Turbulence Models for Predicting Transitional Flows, Int. J. Eng. Sci, vol. 31, no. 6, pp. 831-840,1993.

  2. Asgharzadeh, H., Firoozabadi, B., and Afshin, H., Experimental Investigation of Effects of Baffle Configurations on the Performance of a Secondary Sedimentation Tank, Sci. Iran., vol. 18, no. 4, pp. 938-949, 2011.

  3. Deininger, A., Gimthert, F.W., and Wilderer, P. A., The Influence of Currents on Circular Secondary Clarifier Performance and Design, Water Sci. Technol, vol. 34, no. 3, pp. 405-412, 1996.

  4. Deininger, A., Holthausen, E., and Wilderer, P.A., Velocity and Solids Distribution in Circular Secondary Clarifiers: Full Scale Measurements and Numerical Modelling, Water Res., vol. 32, no. 10, pp. 2951-2958, 1998.

  5. Drew, D.A. and Lahey, R.T., The Virtual Mass and Lift Force on a Sphere in Rotating and Straining Inviscid Flow, Int. J. Multiphase Flow, vol. 13, no. 1, pp. 113-121, 1987.

  6. Fan, L., Xu, N., Ke, X., and Shi, H., Numerical Simulation of Secondary Sedimentation Tank for Urban Wastewater, Chin. J. Chem. Eng., vol. 38, no. 5, pp. 425-433, 2007.

  7. Farrow, J.B., Fawell, P.D., Johnston, R.R.M., Nguyen, T.B., Rudman, M., Simic, K., and Swift, J.D., Recent Developments in Techniques and Methodologies for Improving Thickener Performance, Chem. Eng. J, vol. 80, no. 1,pp. 149-155,2000.

  8. Ganjare, A.V. and Patwardhan, A.W., CFD Simulations of Single-Phase Flow in Settling Tanks: Comparison of Turbulence Models, Indian Chem. Eng., vol. 62, no. 4, pp. 413-426, 2020.

  9. Goula, A.M., Kostoglou, M., Karapantsios, T.D., and Zouboulis, A.I., A CFD Methodology for the Design of Sedimentation Tanks in Potable Water Treatment: Case Study: The Influence of a Feed Flow Control Baffle, Chem. Eng. J, vol. 140, no. 1, pp. 110-121,2008a.

  10. Goula, A.M., Kostoglou, M., Karapantsios, T.D., and Zouboulis, A.I., The Effect of Influent Temperature Variations in a Sedimentation Tank for Potable Water Treatment-A Computational Fluid Dynamics Study, Water Res, vol. 42, no. 13, pp. 3405-3414,2008b.

  11. Jayanti, S. and Narayanan, S., Computational Study of Particle-Eddy Interaction in Sedimentation Tanks, J. Environ. Eng., vol. 130, no. 1, pp. 37-49,2004.

  12. Kantoush, S.A., De Cesare, G., Boillat, J.L., and Schleiss, A.J., Flow Field Investigation in a Rectangular Shallow Reservoir Using UVP, LSPIV and Numerical Modelling, Flow Meas. Instrum, vol. 19, no. 3, pp. 139-144,2008.

  13. Luna, F.D.T., Silva, A.G., Fukumasu, N.K., Bazan, O., Gouveia, J.H.A., Moraes, D., Yanagihara, J.I., and Vianna, A.S., Fluid Dynamics in Continuous Settler, Chem. Eng. J., vol. 362, pp. 712-720,2019.

  14. Lyn, D.A. and Rodi, W., Turbulence Measurements in Model Settling Tank, J. Hydraul. Eng., vol. 116, no. 1,pp. 3-21, 1990.

  15. Mali, R.G. and Patwardhan, A.W., Characterization of Onset of Entrainment in Stirred Tanks, Chem. Eng. Res. Des., vol. 87, no. 7, pp. 951-961, 2009.

  16. Matko, T., Fawcett, N., Sharp, A., and Stephenson, T., Recent Progress in the Numerical Modelling of Wastewater Sedimentation Tanks, Process Saf. Environ. Prot., vol. 74, no. 4, pp. 245-258, 1996.

  17. Mei, R. and Klausner, J.F., Shear Lift Force on Spherical Bubbles, Int. J. Heat Fluid Flow, vol. 15, no. 1, pp. 62-65, 1994.

  18. Morsi, S.A. and Alexander, A.J., An Investigation of Particle Trajectories in Two-Phase Flow Systems, J. FluidMech, vol. 55, no. 2, pp. 193-208, 1972.

  19. Patziger, M., Computational Fluid Dynamics Investigation of Shallow Circular Secondary Settling Tanks: Inlet Geometry and Performance Indicators, Chem. Eng. Res. Des., vol. 112, pp. 122-131,2016.

  20. Rostami, F., Shahrokhi, M., Said, M.A.M., Abdullah, R., and Syafalni, S., Numerical Modeling on Inlet Aperture Effects on Flow Pattern in Primary Settling Tanks, Appl. Math. Modell, vol. 35, no. 6, pp. 3012-3020,2011.

  21. Saffman, P.G., The Lift on a Small Sphere in a Slow Shear Flow, J. Fluid Mech, vol. 22, no. 2, pp. 385-400, 1965.

  22. Saffman, P.G., The Lift on a Small Sphere in a Slow Shear Flow-Corrigendum, J. Fluid Mech, vol. 31, no. 3,p. 624,1968.

  23. Sardeshpande, M.V., Juvekar, V.A., and Ranade, V.V., Solid Suspension in Stirred Tanks: UVP Measurements and CFD Simulations, Can. J. Chem. Eng., vol. 89,no.5,pp. 1112-1121,2011.

  24. Schiller, L. and Naumann, A., On the Basic Calculations of Gravity Processing, Z. Ver. Dtsch. Ing., vol. 77, pp. 318-321,1933.

  25. Stanko, H., Michal, H., Kristna, G., Veronika, G., and Tom, M., CFD Analysis of Experimental Adjustments on Wastewater Treatment Sedimentation Tank Inflow Zone, Monatsh. Chem., vol. 148, no. 3, pp. 585-591,2017.

  26. Takeda, Y., Velocity Profile Measurement by Ultrasonic Doppler Method, Exp. Therm. Fluid Sci., vol. 10, no. 4, pp. 444-453, 1995.

  27. Tarpagkou, R. and Pantokratoras, A., The Influence of Lamellar Settler in Sedimentation Tanks for Potable Water Treatment-A Computational Fluid Dynamic Study, Powder Technol., vol. 268, pp. 139-149, 2014.

  28. Tchobanoglous, G., Stensel, H., Tsuchihashi, R., and Burton, F., Wastewater Engineering: Treatment and Resource Recovery, New York: McGraw-Hill Education, 2003.

  29. Troshko, A.A. and Hassan, Y.A., A Two-Equation Turbulence Model of Turbulent Bubbly Flows, Int. J. Multiphase Flow, vol. 27, no. 11, pp. 1965-2000, 2001.

  30. Vitasovic, Z.C., Zhou, S., McCorquodale, J.A., and Lingren, K., Secondary Clarifier Analysis Using Data from the Clarifier Research Technical Committee Protocol, Water Environ. Res., vol. 69, no. 5, pp. 999-1007, 1997.

  31. Wang, M.H., Bara, B., Hackman, L., Czarnecki, J., Afacan, A., Nandakumar, K., and Masliyah, J.H., Hydrodynamics in a Gravity Settling Vessel: CFD Modelling with LDA Validation, Can. J. Chem. Eng., vol. 78, no. 6, pp. 1046-1055, 2000.

  32. Zhou, S., Mak, B.W.L., Leong, E., Hon-Shing, K., Shu-Kuen, I., and Tze-Kwan, L., Optimized Centre-Feed Clarifier Design for the Tai Po Sewage Treatment Works, Hong Kong, Water Environ. J., vol. 24, no. 2, pp. 140-146,2010.

によって引用された

  1. Ganjare Amol V., Patwardhan Ashwin W., CFD Study of Effect of Particles on Flow Patterns and Separation in Settling Tank, Journal of Hydraulic Engineering, 149, 1, 2023. Crossref

2601 記事の閲覧数 54 記事のダウンロード 記事の統計
2601 記事の閲覧数 54 記事のダウンロード 1 Crossref 引用数 Google
Scholar 引用数

類似内容の記事:

MODELING OF PARTICLE WET MILLING IN A STIRRED TANK USING CFD/PBE COUPLED APPROACH Multiphase Science and Technology, Vol.36, 2024, issue 1
P. Fede, M. Pigou, J.-Ph. Bayle, Zoé Mercier, Eric Climent
Influence of Internal Circulation on Absorption of Atmospheric CO2 and SO2 in Rain Drop Proceedings of the 26thNational and 4th International ISHMT-ASTFE Heat and Mass Transfer Conference December 17-20, 2021, IIT Madras, Chennai-600036, Tamil Nadu, India, Vol.0, 2021, issue
T. V. Binu , Sreenivas Jayanti
STUDY ON PARTICLE DEPOSITION CHARACTERISTICS ON THE OUTER SURFACE OF TUBE BUNDLE HEAT EXCHANGER International Heat Transfer Conference 17, Vol.19, 2023, issue
Zhimin Han, Yanfeng Li, Jinhui Li, Zhiming Xu
COMPREHENSIVE COLLISION MODEL FOR MULTIDIMENSIONAL ENGINE SPRAY COMPUTATIONS Atomization and Sprays, Vol.19, 2009, issue 7
Rolf D. Reitz, Achuth Munnannur
INFLUENCE OF ATOMIZATION AND SPRAY PARAMETERS ON THE FLAME SPRAY PROCESS FOR NANOPARTICLE PRODUCTION Atomization and Sprays, Vol.24, 2014, issue 6
C. D. Rosebrock, L. Madler, Dirceu Noriler, H. F. Meier, Udo Fritsching

最新号

PARAMETRIC STUDY AND DEVELOPMENT OF A CORRELATION FOR NUSSELT NUMBER IN NANOFLUID JET IMPINGEMENT Deepak Kumar Sethy, Pandaba Patro NUMERICAL ANALYSIS FOR EFFECTS OF GRID SPACER VANE ON FLOW-THERMAL CHARACTERISTICS OF TWO PHASE FLOW IN A 5 × 5 ROD BUNDLE Satish Dhurandhar, Shobha Lata Sinha, Shashi Kant Verma WELL-BALANCED ALGORITHM AND HEIGHT FUNCTION METHOD FOR DYNAMIC CONTACT ANGLE IN TWO-PHASE SYSTEMS Van-Quan Hoang, Guillaume Vinay, Olivier Laget, Adele Poubeau, Yanzhi Zhang, Frederic Plourde, Matthieu Fenot ASSESSMENT OF CLASSIC MULTIPHASE FLOW MODELS IN SHALE GAS WELLS Chang Hong Gao

近刊の記事

THERMAL AND HYDRODYNAMIC ANALYSIS OF NANOFLUID FLOW IN A CIRCULAR PIPE USING EULER-GRANULAR MIXTURE MODEL Sameer Sahu, Pandaba Patro, Hrushikesh Barik Assessment of Classic Multiphase Flow Models in Shale Gas Wells CHANG GAO Well-balanced algorithm and Height Function method for dynamic contact angle in two-phase systems Van Quan HOANG, Guillaume VINAY, Olivier Laget, Adele Poubeau, Frederic PLOURDE, Matthieu FENOT, Yanzhi Zhang
Begell Digital Portal Begellデジタルライブラリー 電子書籍 ジャーナル 参考文献と会報 リサーチ集 価格及び購読のポリシー Begell House 連絡先 Language English 中文 Русский Português German French Spain