Publicou 4 edições por ano
ISSN Imprimir: 2169-2785
ISSN On-line: 2167-857X
Indexed in
ENHANCEMENT OF BOILING HEAT TRANSFER ON HYDROPHOBIC FLUOROPOLYMER COATINGS
RESUMO
This paper presents results of an experimental study of the effect of hydrophobic fluoropolymer coating on the multiscale characteristics of heat transfer at water boiling. New experimental data on the dynamics of vapor bubble growth and detachment, the evolution of contact line, the nucleation site density, and heat transfer coefficient were obtained using high-speed imaging techniques, including infrared thermography and video recording from the bottom side of the transparent heater. It was shown that using a hydrophobic fluoropolymer coating leads to heat transfer enhancement, to a decrease of the surface temperature at the onset of boiling, to an increase of nucleation site density, and to significant change in the dynamics of growth and departure of vapor bubbles and the evolution of the triple contact line.
-
Attinger, D., Frankiewicz, C., Betz, A.R., Schutzius, T.M., Ganguly, R., Das, A., Kim, C.J., and Megaridis, C.M., Surface Engineering for Phase Change Heat Transfer: A Review, MRS Energy Sustainability, vol. 1, no. E4, 2014. DOI: 10.1557/mre.2014.9.
-
Betz, A.R., Jenkins, J., and Attinger, D., Boiling Heat Transfer on Superhydrophilic, Superhydrophobic, and Superbiphilic Surfaces, Int. J. Heat Mass Transf., vol. 57, no. 2, pp. 733–741, 2013.
-
Bourdon, B., Bertrand, E., Di Marco, P., Marengo, M., Rioboo, R., and De Coninck, J., Wettability Influence on the Onset Temperature of Pool Boiling: Experimental Evidence onto Ultra-Smooth Surfaces, Adv. Colloid Interf. Sci., vol. 221, pp. 34–40, 2015.
-
Gatapova, E.Y., Shonina, A.M., Safonov, A.I., Sulyaeva, V.S., and Kabov, O.A., Evaporation Dynamics of a Sessile Droplet on Glass Surfaces with Fluoropolymer Coatings: Focusing on the Final Stage of Thin Droplet Evaporation, Soft Matter., vol. 14, no. 10, pp. 1811–1821, 2018.
-
Gerardi, C., Buongiorno, J., Hu, L.W., and McKrell, T., Study of Bubble Growth in Water Pool Boiling through Synchronized, Infrared Thermometry and High-Speed Video, Int. J. Heat Mass Transf., vol. 53, nos. 19-20, pp. 4185–4192, 2010.
-
Jo, H., Ahn, H.S., Kang, S., and Kim, M.H., A Study of Nucleate Boiling Heat Transfer on Hydrophilic, Hydrophobic and Heterogeneous Wetting Surfaces, Int. J. Heat Mass Transf., vol. 54, nos. 25-26, pp. 5643–5652, 2011.
-
Jung, S. and Kim, H., An Experimental Method to Simultaneously Measure the Dynamics and Heat Transfer Associated with a Single Bubble during Nucleate Boiling on a Horizontal Surface, Int. J. Heat Mass Transf., vol. 73, pp. 365–375, 2014.
-
Kandlikar, S.G., A Theoretical Model to Predict Pool Boiling CHF Incorporating Effects of Contact Angle and Orientation, J. Heat Transf., vol. 123, no. 6, pp. 1071–1079, 2001.
-
Kim, J.S., Girard, A., Jun, S., Lee, J., and You, S.M., Effect of Surface Roughness on Pool Boiling Heat Transfer of Water on Hydrophobic Surfaces, Int. J. Heat Mass Transf., vol. 118, pp. 802–811, 2018.
-
Labuntsov, D.A. and Yagov, V.V., Growth Rate of Vapor Bubbles in Boiling, Trans. Moscow Power Institute: Heat Mass Exchange Proc. Apparatuses, vol. 268, pp. 3–15, 1975.
-
Lv, Y., Liu, M.Y., Hui, L.F., Pavlenko, A.N., Surtaev, A.S., and Serdyukov, V.S., Heat Transfer and Fouling Rate at Boiling on Superhydrophobic Surface with TiO2 Nanotube-Array Structure, J. Eng. Thermophys., vol. 28, no. 2, 2019. DOI: 10.1134/S1810232819.
-
Malavasi, I., Teodori, E., Moita, A.S., Moreira, A.L., and Marengo, M., Wettability Effect on Pool Boiling: A Review, in Encyclopedia Two-Phase Heat Transfer and Flow III, J.R. Thome, Ed., Singapore: World Scientific, pp. 1–61, 2018.
-
Nam, Y., Wu, J., Warrier, G., and Ju, Y.S., Experimental and Numerical Study of Single Bubble Dynamics on a Hydrophobic Surface, J. Heat Transf., vol. 131, no. 12, p. 121004, 2009.
-
Safonov, A.I., Sulyaeva, V.S., Gatapova, E.Y., Starinskiy, S.V., Timoshenko, N.I., and Kabov, O.A., Deposition Features and Wettability Behavior of Fluoropolymer Coatings from Hexafluoropropylene Oxide Activated by NiCr Wire, Thin Solid Films, vol. 653, pp. 165–172, 2018.
-
Surtaev, A.S., Serdyukov, V.S., and Pavlenko, A.N., Nanotechnologies for Thermophysics: Heat Transfer and Crisis Phenomena at Boiling, Nanotechnol. Russ., vol. 11, nos. 11-12, pp. 696–715, 2016.
-
Surtaev, A., Serdyukov, V., Zhou, J., Pavlenko, A., and Tumanov, V., An Experimental Study of Vapor Bubbles Dynamics atWater and Ethanol Pool Boiling at Low and High Heat Fluxes, Int. J. Heat Mass Transf., vol. 126, pp. 297–311, 2018.
-
Teodori, E., Valente, T., Malavasi, I., Moita, A.S., Marengo, M., and Moreira, A.L.N., Effect of Extreme Wetting Scenarios on Pool Boiling Conditions, Appl. Therm. Eng., vol. 115, pp. 1424–1437, 2017.
-
Voglar, J., Gregorcic, P., Zupancic, M., and Golobic, I., Boiling Performance on Surfaces with Capillary-Length-Spaced One- and Two-Dimensional Laser-Textured Patterns, Int. J. Heat Mass Transf., vol. 127, pp. 1188–1196, 2018.
-
Shen Biao, Mine Tomosuke, Iwata Naoki, Hidaka Sumitomo, Takahashi Koji, Takata Yasuyuki, Deterioration of boiling heat transfer on biphilic surfaces under very low pressures, Experimental Thermal and Fluid Science, 113, 2020. Crossref
-
Ijaola Ahmed Olanrewaju, Bamidele Emmanuel Anuoluwa, Akisin Cletus John, Bello Idris Temitope, Oyatobo Abiola Tunde, Abdulkareem Abdullah, Farayibi Peter Kayode, Asmatulu Eylem, Wettability Transition for Laser Textured Surfaces: A Comprehensive Review, Surfaces and Interfaces, 21, 2020. Crossref
-
Orman Łukasz J., Radek Norbert, Pietraszek Jacek, Szczepaniak Marcin, Analysis of Enhanced Pool Boiling Heat Transfer on Laser—Textured Surfaces, Energies, 13, 11, 2020. Crossref
-
Safonov Alexey I., Kuznetsov Denis V., Surtaev Anton S., Fabrication of Hydrophobic Coated Tubes for Boiling Heat Transfer Enhancement, Heat Transfer Engineering, 42, 16, 2021. Crossref
-
Chen Jingtan, Ahmad Shakeel, Cai Junjie, Liu Huaqiang, Lau Kwun Ting, Zhao Jiyun, Latest progress on nanotechnology aided boiling heat transfer enhancement: A review, Energy, 215, 2021. Crossref
-
Fedoseev A V, Surtaev A S, Moiseev M I, Ostapchenko A E, Lattice Boltzmann simulation of bubble evolution at boiling on surfaces with different wettability, Journal of Physics: Conference Series, 1677, 1, 2020. Crossref
-
Može Matic, Senegačnik Matej, Gregorčič Peter, Hočevar Matej, Zupančič Matevž, Golobič Iztok, Laser-Engineered Microcavity Surfaces with a Nanoscale Superhydrophobic Coating for Extreme Boiling Performance, ACS Applied Materials & Interfaces, 12, 21, 2020. Crossref
-
Kochkin Dmitry Y., Arkhipov Vyacheslav E., Zaitsev Dmitry V., Frolov Lopson B., Kabov Oleg A., Wettability of graphene-coated copper substrates, THERMOPHYSICAL BASIS OF ENERGY TECHNOLOGIES (TBET 2020), 2337, 2021. Crossref
-
Gao Linsong, Lyu Jizu, Bai Minli, Li Yang, Gao Dongdong, Shi Lin, The microchannel combined hydrophobic nanostructure for enhancing boiling heat transfer, Applied Thermal Engineering, 194, 2021. Crossref
-
Surtaev A. S., Serdyukov V. S., Malakhov I. P., Features of Boiling Heat Transfer at Various Pressures on Hydrophilic/Hydrophobic Surfaces, Journal of Engineering Thermophysics, 29, 4, 2020. Crossref
-
Kochkin D Y, Mungalov A S, Derevyannikov I A, Dynamics of bubble growth under a heated substrate, Journal of Physics: Conference Series, 2119, 1, 2021. Crossref
-
Kochkin D Y, Kurenya A G, Zaitsev D V, Kabov O A, Experimental study of the wettability of silicon substrates coated with vertically oriented carbon nanotubes, Journal of Physics: Conference Series, 1677, 1, 2020. Crossref
-
Volodin O. A., Pecherkin N. I., Pavlenko A. N., Heat Transfer Enhancement at Boiling and Evaporation of Liquids on Modified Surfaces—A Review, High Temperature, 59, 2-6, 2021. Crossref
-
Vladimirov V Yu, Chinnov E A, Heat transfer enhancement when boiling on finned surfaces, Journal of Physics: Conference Series, 1867, 1, 2021. Crossref
-
Može Matic, Hadžić Armin, Zupančič Matevž, Golobič Iztok, Boiling heat transfer enhancement on titanium through nucleation-promoting morphology and tailored wettability, International Journal of Heat and Mass Transfer, 195, 2022. Crossref
-
Serdyukov Vladimir, Starinskiy Sergey, Malakhov Ivan, Safonov Alexey, Surtaev Anton, Laser texturing of silicon surface to enhance nucleate pool boiling heat transfer, Applied Thermal Engineering, 194, 2021. Crossref
-
Liu Cheng, Yu Hang, Experimental Investigations on Heat Transfer Characteristics of Direct Contact Liquid Cooling for CPU, Buildings, 12, 7, 2022. Crossref
-
Serdyukov Vladimir, Patrin Georgy, Malakhov Ivan, Surtaev Anton, Biphilic surface to improve and stabilize pool boiling in vacuum, Applied Thermal Engineering, 209, 2022. Crossref